Influence of water cut and rates of cooling on oil flow
- Authors: Ismayilova F.B.1
-
Affiliations:
- Азербайджанский государственный университет нефти и промышленности
- Issue: Vol 3, No 4 (2021)
- Pages: 109-116
- Section: Articles
- URL: https://journal-vniispk.ru/2707-4226/article/view/125880
- DOI: https://doi.org/10.54859/kjogi99714
- ID: 125880
Cite item
Full Text
Abstract
Oils with anomalous properties are characterized by large values of density, viscosity, high content of paraffinic hydrocarbons and asphaltene-resinous substances (up to 30%), high pour point (35–38°C), which increases the likelihood of complications in the processes of production, field gathering and oil treatment. Therefore, for many countries with cold climatic conditions, the problem of improving the low-temperature properties of oils is one of the most pressing problems in the production and transportation of hard-to-recover oils. Recent studies show that the rates of heating / cooling processes have a great influence on the rheological properties of natural oil mixtures during heat treatment. The experience of operating oil fields shows that in oil gathering and transportation systems, due to the water cut of oils and the aggressiveness of formation waters, persistent oil emulsions are often formed, which complicate the commercial preparation of oils. The article presents the results of studies of the influence of the water cut factor on the transportation of well products, as well as the effect of the cooling rate on the pour point of oil emulsions. Laboratory studies have shown that an increase in the water content in emulsions of more than 40% leads to a significant increase in viscosity over the entire temperature range. It is also shown that an increase in water cut increases the pour point of oil by 7-14°С.
Keywords
Full Text
About the authors
F. B. Ismayilova
Азербайджанский государственный университет нефти и промышленности
Email: fidan.ismayilova.2014@mail.ru
канд. техн. наук, доцент Баку
References
- Исмайылов Г.Г., Серкебаева Б.С., Адыгезалова М.Б. О некоторых проблемах промысловой подготовки нефти и воды. – Известия Высших технических учебных заведений Азербайджана, т. 18, №1 (2016), с. 29–38. // Ismaiylov G.G., Serkebaeva B.S., Adygezalova M.B. O nekotorykh problemakh promyslovoy podgotovki nefti i vody [About some problems of field preparation of oil and water]. – Izvestiya Vysshikh tekhnicheskikh uchebnykh zavedeniy Azerbaydzhana [Bulletins of the Higher Technical Educational Institutions of Azerbaijan], v. 18, №1 (2016), pp. 29–38.
- Касымов Т.Н. Совершенствование технологии сбора и транспорта парафинистых нефтей. – Алматы, Гылым, 2001, 180 с. // Kasymov T.N. Sovershenstvovanie tekhnologii sbora i transporta parafinistykh neftey [Improving the technology of collecting and transporting of paraffinic oils]. – Almaty, Gylym, 2001, 180 p.
- Карабалин У.С., Курбанбаев М.И., Муллаев Б.Т. и др. Совершенствование промысловой подготовки нефти на месторождениях с высокой обводненностью продукции (на примере месторождения Узень). – Материалы международной научно-практической конференции «Современные проблемы нефтегазового комплекса Казахстана», 23–25 Февраля 2011 г., Актау, т. 2, с. 574–582. // Karabalin U.S., Kurbanbaev M.I., Mullaev B.T. and others. Sovershenstvovanie promyslovoy podgotovki nefti na mestorozhdeniyakh s vysokoy obvodnennost'yu produktsii (na primere mestorozhdeniya Uzen') [Improvement of field preparation of oil in fields with high water cut (on the example of the Uzen field)]. – Materialy mezhdunarodnoy nauchno-prakticheskoy konferentsii «Sovremennye problemy neftegazovogo kompleksa Kazakhstana» [Proceedings of the international scientific and practical conference "Modern problems of the oil and gas complex of Kazakhstan"], February, 23–25, 2011, Aktau, v. 2, pp. 574–582.
- Байков Н.М., Позднышев Б.Н., Мансуров Р.И. Сбор и промысловая подготовка нефти, газа и воды. – М., Недра, 1981, 261 с. // Baykov N.M., Pozdnyshev B.N., Mansurov R.I. Sbor i promyslovaya podgotovka nefti, gaza i vody [Collection and field preparation of oil, gas and water]. – Moscow, Nedra, 1981, 261 p.
- Гумбатов Г.Г., Дашдиев Р.А. Химические реагенты, применяемые при добыче, подготовке нефти и газа. – Баку, Элм, 1999, 200 с. // Gumbatov G.G., Dashdiev R.A. Khimicheskie reagenty, primenyaemye pri dobyche, podgotovke nefti i gaza [Chemical reagents used in the production, treatment of oil and gas]. – Baku, Elm, 1999, 200 p.
- Небогина Н.А., Прозорова И.В. Юдина Н.В. Особенности формирования и осадкообразования водонефтяных эмульсий. – Нефтепереработка и нефтехимия, 2008, №1, с. 21–23. // Nebogina N.A., Prozorova I.V. Yudina N.V. Osobennosti formirovaniya i osadkoobrazovaniya vodoneftyanykh emul'sii [Features of the formation and sedimentation of oil-water emulsions]. – Neftepererabotka i neftekhimiya [Oil refining and petrochemistry], 2008, №1, pp. 21–23.
- Исмайылов Г.Г., Сафаров Н.М., Келова И.Н. О новом подходе к структурно-реологическим свойствам водонефтяных эмульсий. – Вестник Азербайджанской Инженерной Академии, 2011, т. 3, № 2, с. 81–94. // Ismaiylov G.G., Safarov N.M., Kelova I.N. O novom podkhode k strukturno-reologicheskim svoystvam vodoneftyanykh emul'sii [On a new approach to the structural-rheological properties of oil-water emulsions]. – Vestnik Azerbaydzhanskoy Inzhenernoy Akademii [Bulletin of the Azerbaijan Engineering Academy], 2011, v. 3, № 2, pp. 81–94.
- Лутошкин Г.С. Сбор и подготовка нефти, газа и воды. – М., Недра, 1987, 183 с. // Lutoshkin G.S. Sbor i podgotovka nefti, gaza i vody [Collection and preparation of oil, gas and water]. – Moscow, Nedra, 1987, 183 p.
- Евдокимов И.Н. Нанотехнология управления свойствами природных нефтегазовых флюидов. – М., Макс-Пресс, 2010, 364 с. // Yevdokimov I.N. Nanotekhnologiya upravleniya svoystvami prirodnykh neftegazovykh flyuidov [Nanotechnology for controlling the properties of natural oil and gas fluids]. – Moscow, Maks-Press, 2010, 364 p.
Supplementary files
